Postal Remaps

All Mk6 Transits and MK7 2006-2010 Ford Transit Postal Remap Tuning for all 2200, 2400 & 3200cc models including 85, 100, 110, 115, 125, 130, 140, 200ps versions, Mondeo’s, Connects, Sprinters, VW LT’s later VW T4’s & all VW T5’s can be tuned "by post" - just send in your ECU & we will tune it in our workshop & post it back the same day...  results are guaranteed & if you want the mapping fine tuned or need even more power or MPG gains, just send it back for an adjustment, there is no extra charge.

Many cars & vans ecus can be tuned this way whether you are in the UK or Australia, or Hong Kong etc..

From just £150, Vantuner’s postal remap van tuning service is a great budget option that saves bargain hunters the pitfalls of tuning boxes or having to trawl the net for a cheap car remapper pretending to be a van specialist.

Transits

On Mk6 Transits, ('00-06) the ECU is accessed under the bonnet, on the right-hand side of the bulkhead up near the coolant tank. Held by two 10mm hex head nuts, one either side, and  one 10mm hex bolt in the centre, that secures the wiring loom connector plug.  Disconnect the battery 1st.

Remove the loom connector bolt 1st, pull out the wiring loom connecting plug & push it to one side, then remove the two nuts, followed by a rubber gasket & it will pull out. The threads that the two nuts live on get corroded, so clean & oil them prior to removal.

When you refit the ECU, be careful to line up the loom connector dead square to the unit & push it home so pins are aligned prior to tightening, after refitting & reconnecting the battery you may need to enter  the radio code and if you dont have it, let me know the radio serial number & i will calculate it for you.  ( on standard ford radios )

Mk7 2006-2010 Ford Transit Postal Remap Tuning for all 2200, 2400 & 3200cc models including 85, 100, 110, 115, 125, 130, 140, 200ps versions

Under bonnet, far right, look for an upside down white sticker saying " visteon " on a 6x6x2" aluminium box.. thats your ECU..

Disconnect your battery before you start work removing the ECU.

You need a regular size hacksaw to cut a slot in the security bolt secures the cover of the ECU connector. File out the slot a little , insert a flat screwdriver & remove the bolt. ( I used a stumpy ) . The ECU then just unbolts after you have unclipped the wiring block connectors. I will send you a new bolt with your ECU , this is the original type bolt from ford, which has a star drive head, you can fully tighten it & break the head of automatically , the ECU is then secure again.. which would slow down any theft attempt that involves an ECU swap !

If you use Royal Mail Special delivery you can include cash, as it's covered for loss. Keep a note of the ECU ID numbers.
All relevant ID is on the left of the ECU sticker, example –

TROT ( BIG BOLD) DPC-510 97AB-12A650-AA

ID sticker for Mk6 TDDI ECU's

Ford Connects  

The main ECU that you need to send is under the drivers foot-well carpet on right hand drive vans, near your gas pedal - disconnect the battery first, unplug and unattach the ECU and leave battery disconnected till after ECU is reinstalled, as with all ECU's sent by post, make a note of the ID numbers from it prior to sending.

VW LT46 &  LT35 Remap or speed limiter removal by post

The LT can have its speed limiter removed, raised, or lowered ... the  ECU on 2.8 litre models is located in the interior, behind a big plastic panel that the ashtray clips into - remove ashtray, remove blanking panel below, remove screw that is hidden behind. On each lower edge on the floor there is one screw each side of the plastic panel to remove, the plastic panel will then pull out and you can get the ECU out easily once removed. Call if you are unsure of the way the clips work on the wiring plugs. Look at the pics below but note, on earlier 2.5's open the bonnet and look under the battery - the ECU lives there and it just unclips. Look at the pics below.

Packing

Please put a self addressed jiffy bag in with your ecu if you are not using a box, size "H" is ideal – Let us know you have sent it – address is Vantuner, PO Box430 Ruislip, HA4 4GB, send by Royal Mail only, the PO Box can't accept mail from couriers.

Payment

Include cash (it’s covered for loss if you use Royal Mail Special Delivery) or send a Paypal payment to vantuner@live.com 

Please contact us for further help on whether your car or van can be tuned by post & what gains are possible. As with our on site remaps happiness is guaranteed or your money back.

Postal van tuning service for Transits, Connects, Sprinters, later VW T4’s, all VW T5’s, & most V.A.G group TDI‘s up to 2008.

Sprinters, T4’s, T5’s, & most VAG group TDI PD/VP vehicles, all possible by post.

A 125TDCI Transit ECU have its speed limiter removed